Home » News » Tesla » Tesla Model S ranks highest in NHTSA crash-tests
Independent testing by the National Highway Traffic Safety Administration (NHTSA) has awarded the Tesla Model S a 5-star safety rating, not just overall, but in every subcategory without exception. Approximately one percent of all cars tested by the federal government achieve 5 stars across the board. NHTSA does not publish a star rating above 5, however safety levels better than 5 stars are captured in the overall Vehicle Safety Score (VSS) provided to manufacturers, where the Model S achieved a new combined record of 5.4 stars.

Of all vehicles tested, including every major make and model approved for sale in the United States, the Model S set a new record for the lowest likelihood of injury to occupants. While the Model S is a sedan, it also exceeded the safety score of all SUVs and minivans. This score takes into account the probability of injury from front, side, rear and rollover accidents.

The Model S has the advantage in the front of not having a large gasoline engine block, thus creating a much longer crumple zone to absorb a high speed impact. This is fundamentally a force over distance problem – the longer the crumple zone, the more time there is to slow down occupants at g loads that do not cause injuries. Just like jumping into a pool of water from a tall height, it is better to have the pool be deep and not contain rocks. The Model S motor is only about a foot in diameter and is mounted close to the rear axle, and the front section that would normally contain a gasoline engine is used for a second trunk.

For the side pole intrusion test, considered one of the most difficult to pass, the Model S was the only car in the "good" category among the other top one percent of vehicles tested. Compared to the Volvo S60, which is also 5-star rated in all categories, the Model S preserved 63.5 percent of driver residual space vs. 7.8 percent for the Volvo. Tesla achieved this outcome by nesting multiple deep aluminum extrusions in the side rail of the car that absorb the impact energy (a similar approach was used by the Apollo Lunar Lander) and transfer load to the rest of the vehicle. This causes the pole to be either sheared off or to stop the car before the pole hits an occupant.

The rear crash testing was particularly important, given the optional third row children's seat. For this, Tesla factory installs a double bumper if the third row seat is ordered. This was needed in order to protect against a highway speed impact in the rear with no permanently disabling injury to the third row occupants. The third row is already the safest location in the car for frontal or side injuries.

Of note, during validation of Model S roof crush protection at an independent commercial facility, the testing machine failed at just above 4 g's. While the exact number is uncertain due to Model S breaking the testing machine, what this means is that at least four additional fully loaded Model S vehicles could be placed on top of an owner's car without the roof caving in. This is achieved primarily through a center (B) pillar reinforcement attached via aerospace grade bolts.

Related Articles

Leave a Comment

Fields marked with * are required
Name *:
Email *:
Comment *:
Code *:
  CAPTCHA
  • Email
  • YouTube
  • RSS
  • Twitter
  • facebook
  • feedburner

Related Specs

  1. 2007 Tesla Roadster

    Engine: 3-phase, 4-pole Electric Motor, Power: 184.9 kw / 248 bhp @ 8500 rpm, Torque: 286.08 nm / 211 ft lbs @ 1 rpm
  2. 2010 Ford Mustang

    Engine: V8, Power: 315 hp @ 6000 rpm, Torque: 325 lb-ft @ 4250 rpm
  3. 2009 Nissan 370Z

    Engine: VQ37VHR Variable Valve Timing NA V6, Power: 332 bhp @ 7000 rpm, Torque: 270 lb-ft. @ 5200 rpm
  4. 2010 Bentley Azure T

    Engine: Twin Turbocharged V8, Power: 500 bhp / 507 PS / 373 kW @ 4,200 rpm, Torque: 738 lb ft / 1,000 Nm @ 3,200 rpm
  5. 2009 Porsche Cayman

    Engine: 6 Cylinder Horizontally Opposed "Boxer", Power: 320 bhpN/A

New Vehicles

Alfa Romeo Giulia Quadrifoglio and Stelvio Quadrifoglio “Alfa Romeo Racing”Alfa Romeo Giulia Quadrifoglio and Stelvio Quadrifoglio “Alfa Romeo Racing”
Alfa Romeo is using this year Geneva Motor Show to introduce two special models. One is Giulia Quadrifoglio and one is Stelvio Quadrifoglio. Both models ...

Concept Cars

First teaser picture of the Mitsubishi Mi-TechFirst teaser picture of the Mitsubishi Mi-Tech
Mitsubishi will unveil during the 2019 Tokyo Motor Show a new special concept. Its name is Mi-Tech and comes with a plug-in hybrid powertrain. ...

Custom Cars

Volkswagen Golf GTI TCR was tweaked out by ABTVolkswagen Golf GTI TCR was tweaked out by ABT
ABT Sportsline has prepared a performance package for the Volkswagen Golf GTI TCR. As you already know, this version of the Golf was launched as a farewell ...

Future Cars

Aston Martin DBX enters final testingAston Martin DBX enters final testing
Aston Martin is ready to follow all those premium manufacturers who decided to launch an SUV. The DBX is really close. Aston Martin’s first SUV has ...

Market News

Lamborghini Huracan surpasses Gallardo production recordLamborghini Huracan surpasses Gallardo production record
When you think at the most popular Lamborghini ever created you think at Gallardo, as it eas the best sold car in the company’s history. Well, starting ...

Gadgets

Karma develops sound for its future electric carsKarma develops sound for its future electric cars
Many electric car manufacturers are exploring new options when it comes to sound. Even an electric car has to sound good. Due to the absence of a loud ...

Various News

Ford Ranger recall issued in US and CanadaFord Ranger recall issued in US and Canada
Once in a while, manufacturers discover some broken parts inside their vehicles, even if they conducted special endurance tests. In this cases, manufacturers ...

Motorsports

This is the new Porsche 99X Electric racer which will compete in 2019-2020 Formule E seasonThis is the new Porsche 99X Electric racer which will compete in 2019-2020 Formule E season
Porsche has officially unveiled the 99X Electric racer. The model was painted in Porsche's traditional motorsport colours of white, black and read and ...

Videos

Video. Watch how Koenigsegg Regera does 0-250-0 mpg in just 32.48 secondsVideo. Watch how Koenigsegg Regera does 0-250-0 mpg in just 32.48 seconds
A couple of weeks ago, the guys from Koenigsegg have announced that the Regera hypercar managed to smash the world record for 0-250-0 mph and also for ...